Electrical items for your water well pump installation.

ELECTRICAL ITEMS
for well pump installation

SQUARE-D FUSE DISCONNECT BOX

$ 56.50 #D211N

Square D general purpose electrical disconnect box rated for 30 amp for 2 screw in plug fuses. Enclosure is Nema 1 for indoor rated safety power disconnect.

SQUARE-D NEMA 3R WATERTIGHT FUSED DISCONNECT

$ 71.50 #D211N3R

Square D NEMA 3R Watertight Fused Disconnect rated 30 amp for 2 screw in plug fuses.

DUAL ELEMENT ( SCREW IN ) TIME DELAY FUSES

$ 17.95 ea

FL5
FL7
FL8
FL9
FL10
FL12

Fusetron 5 amp, 7 amp, 8 amp, 9 amp, 10 amp, and 12 amp screw in plug type dual element time delay fuses.

$ 6.95 ea

FG15
FG20
FG25
FG30

Fusetron 15A+ are available in 15 amp, 20 amp, 25 amp, and 30 amp screw in plug type dual element time delay fuses.

BELL BOX - WIRE CONNECTION BOX Bell boxes are designed for making the electrical cable splice between the submersible pump wire and the underground UF burial wire going from the well to the house. These bell boxes are usually connected to the side of the steel or plastic casing and the wire from your pump comes out of the well top and into the bell box. The UF burial wire bringing power from the house to the well goes into the bell box, and wire nuts are used to connect them. This makes it possible to separate your power at the well, when it becomes necessary to pull the pump.
BB24	$ 22.00	Heavy aluminum 2" wide by 4" high by 2" deep bell box with 3 conduit openings for 1" conduit. Each box comes with a solid blank lid and gasket to keep it water tight.
BB44	$ 26.00	Heavy aluminum 4" wide by 4" high by 2" deep bell box with 5 conduit openings for 1" conduit. Each box comes with a solid blank lid and gasket to keep it water tight.
WIRE NUTS FOR CONNECTION OF UF AND PUMP WIRE
WN12	$ .18 ea	Yellow wire nuts for #12 wire.
WN10	$ .24 ea	Red wire nuts for #10 wire.
WN08	$ .45 ea	Grey wire nuts for #8 wire.

HEAT SHRINK WIRE SPLICE KITS
Heat shrink splice kits are splices for doing under water electrical connection. Each splice kit has the appropriate number of stakons and heat shrink protective splice tubing. To splice for under water, matching color wires are connected together after having slid a shrink tube over the wire. The connection is made with the stakon which is a small metal connector which accepts an end of a wire into each end. The stakon is crimped into place with a crimping tool. The shrink tubing is placed over the stakon, and heat from a lighter or small torch is applied. Keep moving the heat back and forth over the heat shrink tubing until the tubing shrinks down and the sealant ooses out of the ends of the tubing, all around the wire. When properly shrunk, the stakon inside the shrink tubing will show as a raised area of the tube, and the ends will have gel sealant coming out of them.
HS2	$ 3.25	2 wire splice kit for either #12 or #10 pump wire. Kit contains two stakon connectors and two 3" pieces of heat shrink tubing.
HS3	$ 4.50	3 wire splice kit for either #12 or #10 pump wire. Kit contains three stakon connectors and three 3" pieces of heat shrink tubing.
HS4	$ 5.75	4 wire splice kit for either #12 or #10 pump wire. Kit contains four stakon connectors and four 3" pieces of heat shrink tubing.
HS84	$ 9.95	4 wire splice kit for #8 pump wire. Kit contains four #8 stakon connectors and four 6" pieces of heat shrink tubing.
HS64	$ 17.25	4 wire splice kit for #6 pump wire. Kit contains four #6 stakon connectors and four 6" pieces of heat shrink tubing.
HS44	$ 20.25	4 wire splice kit for #4 pump wire. Kit contains four #4 stakon connectors and four 6" pieces of heat shrink tubing.
HSUF	$ 17.95	UF wire splice kit for UF burial cable size #12 UF or #10 UF. Kit contains three #12-#10 stakons, three pieces of shrink tubing about 1-1/2" in length each, and one 8" long large heat shrink tube for shrinking over the top of the smaller splices.
EXTRA STAKON CRIMP CONNECTORS
1210STAKON	$ .28 ea	Single stakon for #12 or #10 pump wire
	$ 22.00 /100	1210STAKON Bag of 100
8STAKON	$ .75 ea	Single stakon for #8 pump wire
6STAKON	$ 1.15 ea	Single stakon for #6 pump wire
4STAKON	$ 1.75 ea	Single stakon for #4 pump wire
2STAKON	$ 2.30 ea	Single stakon for #2 pump wire



3M88	$10.25 ea	3/4" wide x 66' long roll of 3M Scotch brand Super 88 electrical tape

3M88R	$ 10.00 ea	3/4" x 15' 3M Rubber Splicing Tape for extra protection.

ET60	$ 1.40 ea	3/4" wide x 60' long roll of general purpose electrical tape